« previous next »
Pages: [1]

Author Topic: What is this problem?  (Read 1543 times)

Yoni159

  • Full Member
  • ***
  • Posts: 145
    • View Profile
What is this problem?
« on: September 26, 2022, 07:35:57 PM »
Its not from the front wheel its coming from above
Logged

CROSSBOLT

  • Hero Member
  • *****
  • Posts: 7764
  • West Tennessee, USA
    • View Profile
Re: What is this problem?
« Reply #1 on: September 26, 2022, 07:50:52 PM »
Looks like front wheel bearings are missing some balls....
Logged
Karl

Three motorcycles 1960-1977 (restored a 1955 BSA)
Agility 50
Yager 200i
Downtown 300i
Navy tech, Ships Engineer, pilot and aircraft mechanic

Yoni159

  • Full Member
  • ***
  • Posts: 145
    • View Profile
Re: What is this problem?
« Reply #2 on: September 26, 2022, 07:52:58 PM »
Quote from: CROSSBOLT on September 26, 2022, 07:50:52 PM
Looks like front wheel bearings are missing some balls....
its not from the wheel.
Logged

Neil955i

  • Hero Member
  • *****
  • Posts: 4551
  • Cheshire, UK. The older I get, the faster I was...
    • View Profile
Re: What is this problem?
« Reply #3 on: September 26, 2022, 07:55:03 PM »
Head bearings gone?
Logged
Regards & ride safe,
Neil

Current garage:  Kymco DTX360 & Triumph Street Triple 675R
Past bikes: BSA C15. Honda S/wing (GL500). Kawasaki GPz750. BMW K100RS. Kawasaki GPZ900R. Yamaha FJ1200 x2. Sprint. Triumph Daytona 900. Kawasaki ZX-7R. T595 Daytona. Kawasaki ZX-9R x2. Triumph Daytona 955i. X-Town

Ruffus

  • Hero Member
  • *****
  • Posts: 1742
    • View Profile
Re: What is this problem?
« Reply #4 on: September 26, 2022, 08:02:07 PM »
Big head bearing nut loose. Maybe to fix by turning it with a proper tool. Mostly thread demaged. But only to be terminated when some fairing is off.
Logged
Happy and safe scootering, Ruffus

Yoni159

  • Full Member
  • ***
  • Posts: 145
    • View Profile
Re: What is this problem?
« Reply #5 on: September 29, 2022, 04:12:20 AM »
It is dangerous to ride like this maybe more 300-400km i dont havr any money to fix it right know. Maybe i can fix it alone ?
Logged

Neil955i

  • Hero Member
  • *****
  • Posts: 4551
  • Cheshire, UK. The older I get, the faster I was...
    • View Profile
Re: What is this problem?
« Reply #6 on: September 29, 2022, 06:43:08 AM »
A quote from someone who appears to know more than me:
“ They could just be loose. If you don't get them tightened up, they WILL wear out quickly since they are getting hammered over every bump.

If you elevate the front end and tighten the bearings like the shop manual says, the bars will "index" if the races are shot. What I mean is the bars will turn about 10 degrees and stop, require more effort, then stop again so your steering feels notchy. This will eventually affect handling in a very bad way.

I would see if they behave after tightening. If they don't, I'd replace them in a heartbeat.”

My advice? Take the bus until you can afford the repair.
Logged
Regards & ride safe,
Neil

Current garage:  Kymco DTX360 & Triumph Street Triple 675R
Past bikes: BSA C15. Honda S/wing (GL500). Kawasaki GPz750. BMW K100RS. Kawasaki GPZ900R. Yamaha FJ1200 x2. Sprint. Triumph Daytona 900. Kawasaki ZX-7R. T595 Daytona. Kawasaki ZX-9R x2. Triumph Daytona 955i. X-Town

Yoni159

  • Full Member
  • ***
  • Posts: 145
    • View Profile
Re: What is this problem?
« Reply #7 on: September 30, 2022, 02:57:02 AM »
Quote from: Neil955i on September 29, 2022, 06:43:08 AM
A quote from someone who appears to know more than me:
“ They could just be loose. If you don't get them tightened up, they WILL wear out quickly since they are getting hammered over every bump.

If you elevate the front end and tighten the bearings like the shop manual says, the bars will "index" if the races are shot. What I mean is the bars will turn about 10 degrees and stop, require more effort, then stop again so your steering feels notchy. This will eventually affect handling in a very bad way.

I would see if they behave after tightening. If they don't, I'd replace them in a heartbeat.”

My advice? Take the bus until you can afford the repair.
Which part in need to tighten?
https://ibb.co/cvXhDk3
https://ibb.co/2FLVXSB
Logged

Yoni159

  • Full Member
  • ***
  • Posts: 145
    • View Profile
Re: What is this problem?
« Reply #8 on: September 30, 2022, 02:57:38 AM »
Logged

Neil955i

  • Hero Member
  • *****
  • Posts: 4551
  • Cheshire, UK. The older I get, the faster I was...
    • View Profile
Re: What is this problem?
« Reply #9 on: September 30, 2022, 04:37:39 AM »
Honest answer?  I'm out of my comfort zone now.  Presumably it couldn't hurt to check both, but hopefully someone more skilled than I (Crossbolt?  Ruffus?) will pitch in and advise.
Logged
Regards & ride safe,
Neil

Current garage:  Kymco DTX360 & Triumph Street Triple 675R
Past bikes: BSA C15. Honda S/wing (GL500). Kawasaki GPz750. BMW K100RS. Kawasaki GPZ900R. Yamaha FJ1200 x2. Sprint. Triumph Daytona 900. Kawasaki ZX-7R. T595 Daytona. Kawasaki ZX-9R x2. Triumph Daytona 955i. X-Town

Yoni159

  • Full Member
  • ***
  • Posts: 145
    • View Profile
Re: What is this problem?
« Reply #10 on: September 30, 2022, 08:47:46 AM »
Quote from: Neil955i on September 30, 2022, 04:37:39 AM
Honest answer?  I'm out of my comfort zone now.  Presumably it couldn't hurt to check both, but hopefully someone more skilled than I (Crossbolt?  Ruffus?) will pitch in and advise.
someone here was right i checked it very good and its front wheel bearing. I glad it is because its cheaper to replace. Something strange is i replaced them 2 years ago
Logged

Neil955i

  • Hero Member
  • *****
  • Posts: 4551
  • Cheshire, UK. The older I get, the faster I was...
    • View Profile
Re: What is this problem?
« Reply #11 on: September 30, 2022, 08:53:25 AM »
Glad you got to the bottom of it!
Logged
Regards & ride safe,
Neil

Current garage:  Kymco DTX360 & Triumph Street Triple 675R
Past bikes: BSA C15. Honda S/wing (GL500). Kawasaki GPz750. BMW K100RS. Kawasaki GPZ900R. Yamaha FJ1200 x2. Sprint. Triumph Daytona 900. Kawasaki ZX-7R. T595 Daytona. Kawasaki ZX-9R x2. Triumph Daytona 955i. X-Town

CROSSBOLT

  • Hero Member
  • *****
  • Posts: 7764
  • West Tennessee, USA
    • View Profile
Re: What is this problem?
« Reply #12 on: September 30, 2022, 10:17:24 AM »
Quote from: Yoni159 on September 30, 2022, 02:57:38 AM
the lower or the upper?
The tightening of the upper tightens both.
Logged
Karl

Three motorcycles 1960-1977 (restored a 1955 BSA)
Agility 50
Yager 200i
Downtown 300i
Navy tech, Ships Engineer, pilot and aircraft mechanic

Neil955i

  • Hero Member
  • *****
  • Posts: 4551
  • Cheshire, UK. The older I get, the faster I was...
    • View Profile
Re: What is this problem?
« Reply #13 on: September 30, 2022, 02:21:37 PM »
Quote from: Yoni159 on September 30, 2022, 08:47:46 AM
someone here was right i checked it very good and its front wheel bearing. I glad it is because its cheaper to replace. Something strange is i replaced them 2 years ago

Yay!  You were right first time Karl.
Logged
Regards & ride safe,
Neil

Current garage:  Kymco DTX360 & Triumph Street Triple 675R
Past bikes: BSA C15. Honda S/wing (GL500). Kawasaki GPz750. BMW K100RS. Kawasaki GPZ900R. Yamaha FJ1200 x2. Sprint. Triumph Daytona 900. Kawasaki ZX-7R. T595 Daytona. Kawasaki ZX-9R x2. Triumph Daytona 955i. X-Town

CROSSBOLT

  • Hero Member
  • *****
  • Posts: 7764
  • West Tennessee, USA
    • View Profile
Re: What is this problem?
« Reply #14 on: September 30, 2022, 07:59:31 PM »
Quote from: Neil955i on September 30, 2022, 02:21:37 PM
Yay!  You were right first time Karl.
Thanks, I needed that!
Logged
Karl

Three motorcycles 1960-1977 (restored a 1955 BSA)
Agility 50
Yager 200i
Downtown 300i
Navy tech, Ships Engineer, pilot and aircraft mechanic

An Error Has Occurred!

Call to undefined function split()
Back