« previous next »
Pages: [1]

Author Topic: Automatic choke  (Read 6051 times)

scooterman11

  • Jr. Member
  • **
  • Posts: 93
    • View Profile
Automatic choke
« on: June 04, 2012, 02:27:43 AM »
I was putting my agility 50 back together and my needle on my automatic choke broke off, I continued putting it all back to gether and finally started her back up and she was idling crazy up and down and rough idling if i get a new automatic choke will that solve my problem
Logged

blue

  • Hero Member
  • *****
  • Posts: 3935
    • View Profile
Re: Automatic choke
« Reply #1 on: June 04, 2012, 02:48:21 AM »
no Your choke has nothing to do with idling. its only for when you frist start the bike.
you may have to go over everything again on how you put the carb back in.I have ran my scoot
with out the choke on the bike at all. But then I have to kick start it. is it the stock carb.Also you can take a small pin and drop down the hole to block the hole. and tape a penny over the place wear the choke is lol I know its the red neck in me but it works. but then you have to use the kick start.
Logged

zombie

  • You never know do ya!
  • Hero Member
  • *****
  • Posts: 13870
  • Close enough to get the idea!
    • View Profile
Re: Automatic choke
« Reply #2 on: June 04, 2012, 03:56:19 AM »
The up/down idle speed is usually a vacuum leak. Re check everything.
Logged
"They have nothing in their whole imperial arsenal that can break the spirit of one Irishman who doesn't want to be broken."   Bobby Sands...

mono

  • Sr. Member
  • ****
  • Posts: 287
    • View Profile
Re: Automatic choke
« Reply #3 on: June 04, 2012, 10:54:24 AM »
If you break the needle off your choke unit it will have the effect of always having the choke on, therefore it will idle with high rpm and a way too rich mixture when the engine gets warm...

So, when everything else is still OK, your problem should be solved by replacing the bystarter/choke unit.

Logged

scooterman11

  • Jr. Member
  • **
  • Posts: 93
    • View Profile
Re: Automatic choke
« Reply #4 on: June 04, 2012, 07:28:37 PM »
where can I order A automatic choke by starter unit from?
Logged

blue

  • Hero Member
  • *****
  • Posts: 3935
    • View Profile
Re: Automatic choke
« Reply #5 on: June 04, 2012, 09:21:22 PM »
Most scooter shops well have theam .they are all the same for the gy6 scooters.
Logged

zombie

  • You never know do ya!
  • Hero Member
  • *****
  • Posts: 13870
  • Close enough to get the idea!
    • View Profile
Re: Automatic choke
« Reply #6 on: June 05, 2012, 03:14:35 AM »
Logged
"They have nothing in their whole imperial arsenal that can break the spirit of one Irishman who doesn't want to be broken."   Bobby Sands...

mono

  • Sr. Member
  • ****
  • Posts: 287
    • View Profile
Re: Automatic choke
« Reply #7 on: June 05, 2012, 07:00:28 AM »
Quote
Most scooter shops well have theam .they are all the same for the gy6 scooters.

I have one of those that doesn't fit very well on the Kymco carb, and I expect that it's not just my bad luck...

Quote
For ten bucks more you can buy an entire carb.
http://www.ebay.com/sch/i.html?_odkw=gy6+auto+choke&_osacat=0&_trksid=p2045573.m570.l1313&_nkw=gy6+carb.&_sacat=0

I have one of these chinese no-brand Keihin imitation carbs and it's not the same quality as the Kymco one.
On the other hand it does work fine and it's a complete replacement including the choke, which at least fits correctly on that carb.. (beware that your main jet from the Kymco carb might not fit in the chinese carb, mine takes the smaller Keihin type jets with M4 thread)

If you're short on cash and/or time you could buy a cheap carb (and main jet) and try to swap only the choke unit first.
If you're not short on cash and like to do things The Right Way (tm) you're probably best off ordering an OEM Kymco choke....
 
Logged

blue

  • Hero Member
  • *****
  • Posts: 3935
    • View Profile
Re: Automatic choke
« Reply #8 on: June 05, 2012, 06:20:42 PM »
the real kymco carb is better but ya short on cash works good too. just have to make sure it has all the right jets.
Logged

Kenho21

  • Sr. Member
  • ****
  • Posts: 418
  • I live my life 0.402336 kilometers at a time
    • View Profile
Re: Automatic choke
« Reply #9 on: June 05, 2012, 11:36:22 PM »
A little off subject, but does anyone know where to find the gasket that seals the two halves of the carb together? I have found gaskets for the off-brand chinese scoot carbs, but those are different than the Kymco carb gaskets. The only option I found was buying an entire carb from Kymco which was something like $150...
Logged
2009 Kymco Agility 50- 72cc Airsal kit, Uni Free-Flow Air Filter, Main Jet 120, 1500 Contra Spring, 6g Rollers, Malossi Multivar Variator, NCY Exhaust, NCY 80cc Camshaft, Cut CDI, Smooth Boss Drive, MRP Ignition Coil

zombie

  • You never know do ya!
  • Hero Member
  • *****
  • Posts: 13870
  • Close enough to get the idea!
    • View Profile
Re: Automatic choke
« Reply #10 on: June 06, 2012, 04:05:00 AM »
Stadium Yamaha? I don't know if they sell rebuild kits.     Or Treatland... They sell all sorts of carb parts. Mention the forum at both. (CALL)
Logged
"They have nothing in their whole imperial arsenal that can break the spirit of one Irishman who doesn't want to be broken."   Bobby Sands...

Kenho21

  • Sr. Member
  • ****
  • Posts: 418
  • I live my life 0.402336 kilometers at a time
    • View Profile
Re: Automatic choke
« Reply #11 on: June 06, 2012, 05:16:09 PM »
Will do, thanks for the tip. I think I've tried Stadium Yamaha at some point, but not sure, I will try anyway. Thanks again
Logged
2009 Kymco Agility 50- 72cc Airsal kit, Uni Free-Flow Air Filter, Main Jet 120, 1500 Contra Spring, 6g Rollers, Malossi Multivar Variator, NCY Exhaust, NCY 80cc Camshaft, Cut CDI, Smooth Boss Drive, MRP Ignition Coil

An Error Has Occurred!

Call to undefined function split()
Back